Wildfire Recalls Hybrid Bike/Car For ABS Warning Light Issue

 WILDFIRE IS RECALLING CERTAIN MODEL YEAR 2009 WF650-C MOTORCYCLES, MANUFACTURED FROM APRIL 2008 THROUGH JANUARY 2009 FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 122, “MOTORCYCLE BRAKE SYSTEM.” AS BUILT, THESE MOTORCYCLES HAVE A SINGLE BRAKE FLUID RESERVOIR WITH A SINGLE FILLER OPENING AND LACK THE REQUIRED RESERVOIR LABELING. WARNING LAMPS INDICATING BRAKE FAILURE ARE ALSO ABSENT.
Consequence:
  WITHOUT THE REQUIRED BRAKE RESERVOIR LABEL, OPERATORS MAY IMPROPERLY MAINTAIN THE BRAKE SYSTEM. WITH ONLY A SINGLE BRAKE FLUID RESERVOIR FOR THE ENTIRE BRAKE SYSTEM AND NO BRAKE FAILURE INDICATOR LAMP, IN THE EVENT OF ANY BRAKE FLUID LEAK, THE ENTIRE BRAKE SYSTEM COULD FAIL WITHOUT WARNING, INCREASING THE RISK OF A CRASH.Remedy:
  WILDFIRE WILL CONTACT OWNERS, AND DEALERS WILL CORRECT THE MOTORCYCLES, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MARCH 2012. OWNERS MAY CONTACT WILDFIRE AT 740-283-6540.

Kawasaki Recalls 2011 ZX1000 Wiring

Vehicle Make/Model:                                         Model Year(s):

Kawasaki / ZX1000JBFL                               2011
Kawasaki / ZX1000JBL                                 2011
Kawasaki / ZX1000KBFL                              2011
Kawasaki / ZX1000KBL                                 2011

Manufacturer: Kawasaki Motors Corp., U.S.A.

Mfr’s  Report Date: July 07, 2011

NHTSA Campaign ID Number: 11V363000

Component: Electrical System:Wiring

Summary: Kawasaki is recalling certain model year 2011 Ninja ZX-10R/ZX-10R ABS (ZX1000JBF/KBF/KBFL) motorcycles. It is possible for a portion of the wiring harness to become pinched between the rear subframe and the bolt holding the seat cover. This can damage the harness and wiring and result in a short between wires and the frame or within wires, which could result in the engine stopping suddenly.

Consequence: If the motorcycle stalls while being  ridden, there could be a crash resulting in injury or death.

Remedy: Dealers will repair the motorcycle as necessary, and reroute the main harness; free of charge. The manufacturer has not yet provided an owner notification schedule. Owners may contact Kawasaki consumer services department at 1-866-802-9381

Notes: Owners may also contact the National Highway Traffic Safety Administration’s Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9152), or go to  HTTP://WWW.SAFERCAR.GOV

 

 

Polaris Recalls Kingpin & Jackpot Backrest

Vehicle Make/ Model: Victory / Jackpot

Victory / Kingpin

Model Year(s): 2006-2011
2004-2011

Manufacture: Equipment

Potential Number of Units Affected: 1,688

Summery:
Polaris is recalling certain model year 2004-2011 Victory Kingpin Motorcycles and model year 2006-2011 Victory Motorcycle manufactured from Jan. 1, 2004, through May 1, 2011, equipped with accessory seats, part numbers 2876641-01 seat, KIngpin Touring, double backrest and part number 2875961-01, Jackpot Touring w/backrest. The backrest support can seperate from the motorcycle while in use.

Consequences:
The passenger can be injured or fall from the motorcycle should this occur.

Remedy:
Victory will notify owners and dealers will replace the affected seats free of charge. The safety recall is expected to begin on or before August 30, 2011

Notes:
Owners may also contact the National Highway Traffic Safety Administration’s Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to  HTTP://WWW.SAFERCAR.GOV

Yamaha Recalls 2011 FJR1300 Brake Switch

 

Vehicle Make / Model: Yamaha / FJR1300      Model Year(s): 2011

Manufacture: Yamaha Motor Corp., USA           Mfr’s Report Date: June 24, 2011

NHTSA Campaign ID Number: 11V340000      NHTSA Action Nmber: N/A

Component: Exterior Lighting: Brake Lights:Switch

Potential Number of Units Affected:260

Summary:
Yamaha is recalling certain model year 201 FJR1300 motorcycles manufacuted from Jan. 2011 through April 2011. The brake light may not illuminate when the front brake lever is applied because the activating mechanism in the front brake switch can bind.

Consequence:
When th motorcycle operator applies only the brake, the brake light may not come on to alert other drivers, increasing the risk of a crash.

Remedy:
Yamaha dealers will install a new front brake switch free of charge. The safety recall is expected to begin during July 2011. Owners may contact Yamaha at 1-800-962-7926

Notes:
Owners may also contact the National Highway Traffic Safety Administration’s Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9152), or go to  HTTP://WWW.SAFERCAR.GOV

 

Polaris Recalls Indian Kickstand 09-2011

Vehicle Make / Model: Indian / Indian      Model Year(s): 2009-2011

Manufacture: Indian Motorcycle Company

Mfr’s Report Date: June 24, 2011

NHTSA Campaign ID Number: 11v344000       NHTSA Action Number: N/A

Component: Structure:Motorcycle Kickstand/Center Stand

Potential Number of Units Affected:699

Summary:
Polaris is recalling certain model year 2009-2011 Indian Motorcycles for failing to confirm to the requirements of Federal Motor Vehicle Safety Standard No. 123 “Motorcycle controls and displays.” The side stand may not fold rearward an upward if it contacts the ground when the motorcycle is moving forward.

Consequence:
If the stand does not fold rearward and upward while the motorcycle moves forward, the driver’s ability to control the motorcyle could be affected, increasing the risk of a crash.

Remedy:
Dealers will replace the side stand free of charge. The safety recall is expected to being during August 2011. Owners may contact Indian at 651-408-7579

Notes:
Owners may also contact the National Highway Safety Administration’s Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to  HTTP://WWW.SAFERCAR.GOV

Yamaha Recalls FJR1300 Electrical Wiring System

Vehicle Make /Model:  Yamaha/FJR1300                                                              Model Year(s): 2006-2009

Manufacturer: Yamaha Motor Corporation, USA                                                 Mfr’s Report Date: June 24, 2011

Component: Electrical System: Wiring

Potential Number of Units Affected: 9,850

Summary:
Yamaha is recalling certain model year 2006-2009 FJR1300 motorcycles manufactured from Feb. 2006, through March 2009. The ground joint connector of the wire harness could overheat and become deformed, possibly causing an intermittent ground wire connection. If the electrical system is not properly grounded, the ignition system and/ or other electrical components could malfunction, which could cause the engine to stall.

Consequences:
If the motorcycle stalls while being ridden, there could be a crash resulting in injury or death.

Remedy:
Yamaha dealer will install an additional wire sub-lead or, if ground joint connector has already been damaged from overheating, dealer will install a new main wire harness. This service will be performed free of charge. The safety recall is expected to begin during July 2011. Owners may contact Yamaha at 1-800-962-7926

Notes:
Owners may contact the National Highway Traffic Safety Administration’s Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to  HTTP://WWW.SAFERCAR.GOV

Kawasaki Recalls Tire Tubes

Vehicle Make/Model: Kawasaki/VN900D                                                            Model Year(s): 2011

Manufacture: Kawasaki Motors Corp., U.S.A.                                                      Mfr’s Report Date: Jun 02, 2011

NHTSA Campaign ID Number: 11V313000                                                          NHTSA Action Number: N/A

Component: Tires:Tube

Potential Number of Units Affected: 436

Summary:
Kawasaki is recalling certain model year 2011 VN900D, Vulcan Classic LT, Motorcycles. The tire inner tubes have been pinched during the mounting of the tires. Damage to the inner tubes could result in loss of air pressure.

Consequence:
Loss of the air pressure could result in a tire failure, increasing the risk of a crash.

Remedy:
Dealers will replace any damaged tubes free of charge , The Safety recall is expected to begin during June 2011. Owners may contact Kawasaki Consumer Services Department at 1-866-802-9381

Notes:
Owners may also contact the National Highway Traffic Safety Administration’s Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to  HTTP://WWW.SAFERCAR.GOV

KTM Recalls Steering Components

Vehicle Make/Model:                                                                     Model Year(s):
Husaberg/ FE 570S                                                                      2011
Husaberg/ FS 570                                                                         2011
KTM/ 450 EXC                                                                                2011
KTM/ 530 EXC                                                                                2011
KTM/ 690 Enduro R                                                                     2010-11
Manufacturer: KTM North America, Inc                                     Mfr’s Report Date: May 10, 2011
NHTSA Camaign ID Number: 11V300000                                NHTSA Action Number: N/A
Component: Steering: Wheel and Handlebar
Potential Number of Units Affected: 1,228
Summary: KTM is recalling certain model year 2010 and 2011 motorcycles manufactured from November 2009 through November 23, 2010. Due to improper hear treatment, the handlebar clamps develop cracks, allowing the handlebar to move from its set position.
Remedy: Authorized KTM dealers will replace the defective clamps for free of charge. The Safety recall is expected to begin during June 2011. Owners may contact KTM customer service at 1-888-985-6090 for assistance.
Notes: Owners may also contact the National Highway Traffic Administrative Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9253),  or go to HTTP://WWW.SAFERCAR.GOV

Polaris Recalls Steering Component

Vehicle Make / Model: Victory / Cross Country                                                                                                                      Model Year(s): 2011

Manufacturer: Polaris Industries, Inc.                                                                                                                                         Mfr’s Report Date: May 31, 2011

NHTSA Campaign ID Number: 11V305000                                                                                                                               NHTSA Action Number: N/A

Component: Steering : Wheel and Handle Bar

Potential Number of Units Affected: 840

Summary:
Polaris is recalling certain model year 2011 Victory Cross Country Motorcycles manufactured from Jan.1, through April 11,2011. The handlebar clamps and/or risers may have been machined incorrectly which could cause the handlebars to slip in the clamps.

Remedy:
Polaris will notify owners, and dealers will test and replace defective riser/clamp assemblies, free of charge, the safety recall is expected to begin during June 2011. Owners may contact Victory Customer Service @ 1-888-704-5290

Notes:
Owners may also contact the National Highway Traffic Safety Administration’s Vehicle Safety Hotline @ 1-888-327-4236 (TTY 1-800-424-9153) OR GO TO HTTP://WWW.SAFERCAR.GOV .


Ducati Recalls Steering Component

Vehicle Make/ Model: Ducati  / Diavel                                                                                                      Model Year(s): 2011
Ducati / MTS 1200                                                                                                                                                                             2010-2011

Manufacturer: Ducati North America                                                                                                        Mfr’s Report Date: APR 21, 2011

NHTSA Campaign ID Number: 11V253000                                                                                             NHTSA Action Number: N/A

Component: Steering

Potential Number of Units Affected: 1,051

Summery:
Ducati is recalling certain model year 2010-2011 Multistrada 1200, and model year 2011, Diavel Motorcycles, the electronic steering lock may fail to disengage during the motorcycle “key-on” process. This has been linked directly to a certain revision of the hands free device software. It could result in a situation where the motorcycle’s engine might start while the steering lock is still engaged.  A rider could start the motorcycle and attempy to ride away while steering is still locked.

Consequence:
The rider could experience the inability to steer increasing the risk of low speed tip-over or collision, thus increasing the potential for injury to the rider.

Remedy:
The dealer will update the software of the hands free control unit free of charge. The recall is expected to begin during May 2011. Owners may contact Ducati at 1-800-231-6696

Notes:
Owners may also contact the National Highway Traffic Safety Administration’s Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to SaferCar.gov